Author: Shakajin Akinolar
Country: Brunei Darussalam
Language: English (Spanish)
Genre: Life
Published (Last): 15 July 2018
Pages: 239
PDF File Size: 19.16 Mb
ePub File Size: 8.91 Mb
ISBN: 570-1-63222-537-8
Downloads: 64909
Price: Free* [*Free Regsitration Required]
Uploader: Tygomi

If air is escaping through valves, check push rod length. Gasket surface of both head and cylinder. Heavy front end loading.

DOWNLOAD Honda Motorcycle Service Manuals & Owner’s Manual

More than one of these conditions may be causing the trouble and all should be carefully checked. Compression is normal if final readings are within the range specified in Tableand do not indicate more than a 10 psi 0. Wheels not aligned, rims bent, or tires worn manusl damaged.

Engine ground wire loose or broken. Intermittent short circuit due to damaged wire insulation. Factory Service Manuals In Seconds!

Air cleaner EVAP flapper if equipped stuck close or inoperative. A proper compression test should be performed with the engine at normal operating temperature when possible.

Loose spokes models with laced wheels. Ignition not functioning properly possible sensor failure. Does not glow when ignition is turned on prior to operating engine. After completing the cylinder leakage test sedvice and reinstalling the spark plugs, make sure the throttle plate is in the closed position before starting the engine.

With a soap solution [applied around all tester fittings], connect the cylinder leakdown tester to the compressed air source and look for any bubbles that would indicate leakage from the tester. Pre-Ignition or Detonation Knocks or Pings. Pre-Ignition or Detonation Knocks or Pings 1. Cam shonda vtx service manual pdf download gear sevriceor cam bushing s worn. Pdd spark plug s. Rocker arm binding on shaft. In honda vtx service manual pdf download cases, unsatisfactory performance is caused by combustion chamber leakage.

After completing the compression test s and reinstalling the spark plugs, make sure the throttle plate is in the closed position before starting the engine.

Rear fork pivot shaft fasteners loose. Brake drags – insufficient brake pedal or hand lever freeplay, caliper piston worn or damaged, or downolad brake fluid in reservoir. The steel plates clutch driven plates are keyed to the clutch hub, which drives the rear wheel through the transmission and secondary drive belt.

Weak or damaged battery. Spark honda vtx service manual pdf download in bad condition or partially fouled. Brake disc badly worn or warped.

Restricted oil return hose to tank. Remove the air cleaner and set the throttle in the wide open position. Low Oil Pressure 1. Valve guides or seals badly worn or damaged.

Bent push rod s. Shifter engaging parts inside transmission badly worn and rounded. Compression low on first stroke, tends to build up on mnual following strokes, but does not reach normal.

Damaged wire or loose connection at battery terminals, ignition coil or ECM connector.

Toyota Camry Full Repair Manual 2az Fe Engine

When an engine needs repair, it is not always possible to determine definitely beforehand whether repair is possible with only cylinder heads, cylinders, and pistons disassembled, or whether complete engine disassembly is pdd for crankcase repair. Spark plugs btx bad condition, have improper gap or are partially fouled. Non-standard equipment on the front end such as heavy radio receivers, extra lighting equipment, or luggage tends to cause unstable handling.

Front engine mounting bolts loose. Irregular or peaked front tire tread wear. Spark plug cables in bad condition and shorting, cable connections loose or cables connected to incorrect cylinders.

The Troubleshooting section is a guide to diagnose problems. Spark Plug Fouls Repeatedly 1.

Repeat procedure on rear cylinder. If compression is below psi 6. Low oil pressure caused by oil feed pump not functioning properly or oil passages obstructed.